2006 Motor Vehicle Safety Recalls
Bentley
2004 Continental GT>
Insufficient clearance for a brake pipe allows an engine mounted hose clip to perforate the brake pipe causing loss of brake fluid which can catch fire and increase stopping distanceBMW
2005-2006 5, 6-Series; 2006 3, 7-Series>
Faulty automatic transmission parking pawl guide plate prevents the parking lock system from engaging after the transmission is placed in the park position.2006 3-Series>
Incorrectly torqued front suspension control arm and swivel bearing connection bolt could loosen and the bolted connection could break, causing loss of vehicle control. Dealers will inspect and, if necessary, adjust or replace the suspension control arm and the swivel bearing.2006 5 & 6-Series cars>
Nuts securing the front axle control arm tension strut to the front wheel hub comes loose causing a loss of handling and vehicle control.2006 5-, 6-, 7-Series>
Lower rubber rear shock absorber mounting comes out of the housing causing impaired handling and control.D-Chrysler
1999-2000 Breeze, Cirrus, Stratus 2.4>
High pressure power steering hose develops a leak which could cause an underhood fire.2000-2002 Jeep Grand Cherokee>
Electric motor driven cooling fan plastic blades come off and if the hood is open, could hit someone. Dealers will replace the fan modules.2001-2003 Dodge
Durango (w/front bench seats)> Drink spill from the floor mounted cup holder shorts the console power outlet connector located under the seat causing an electrical fire.2002-2006 Jeep Liberty>
Contamination of the front lower ball joints causes corrosion, accelerated wear and eventual separation from the steering knuckle causing a loss of vehicle steering control.2003-2004 Jeep Grand Cherokee (w/Heated Seats)>
Front passenger electric seat heater element catches the seat on fire.2005-2006 Dodge Durango, Caravan, Grand Caravan, Town & Country> Windshield wiper motor armature shaft breaks causing loss of front windshield wiping.
2005-2006 Pacifica>
Stalling can occur because of failure of the fuel pump or software glitch in the power train control module. Dealers will reprogram the power train control module or replace the fuel pump module.2006 Chrysler 300, Charger, Magnum 2.7L & MK25E braking system>
Rear brake lines are too close to the exhaust gas recirculation tube and contact may cause the lines to wear and leak brake fluid resulting in loss of braking force and engine compartment fire. Dealers will install a clip to secure the brake tubes to the right front shock tower.2006 Dakota, Ram>
Four-wheel antilock brake system Electronic Control Unit (ECU) creates a front to rear brake imbalance causing the rear brakes to lock up prematurely during certain braking conditions which results in loss of driver control. Dealers will replace the ABS ECU.2006 Dodge
Durango> Left rear suspension watts link may have been damaged during vehicle assembly and could fail and adversely affect vehicle handling.2006 Dodge Ram 1500>
1) Passenger air bag may deploy with excessive force when certain model rear facing child seats are installed in the right front passenger seat position. Dealers will replace the passenger air bag cushion and reprogram the occupant restraint controller. 2) The front passenger seat belt is unable to secure certain model child seats. Dealers will replace the front passenger seat belt.2006 Dodge Ram 3500 trucks (with dual rear wheels)> No roof mounted cab clearance lamps were installed, which fails to meet DOT requirements.
2006 Durango, Dakota>
Static electric spark coming from the driver causes the turn signal, headlamps or windshield wipers to fail. Dealers will reprogram the body control computer.2006
Durango> Anti-lock brake system control module software program may cause the rear brakes to lock up during certain braking conditions causing loss of vehicle control in certain conditions.2006 Durango>
The wrong occupant restraint controller was installed causing increased risk of injury to the driver in a crash.2006 Jeep Cherokee>
Driver's air bag inflator connector was incorrectly assembled and the air bag may not inflate.2006 Jeep Commander>
Third row seatbelt retractor bracket contacts the belt webbing causing it to fray and fail to restrain the occupant. Dealers will add an injected molded cover to the retractor bracket2006 Jeep Liberty 2WD 3.7L>
Left oxygen sensor wiring harness contacts the exhaust pipe causing an electrical fire.2006 Jeep Liberty> Faulty right front door latch reinforcement plate prevents the secondary door latch from working which increases the possibility the door will open and an unbelted passenger ejected during a rollover.
2006 Jeep Wrangler>
6-speed manual transmission hydraulic clutch master cylinder linkage rod breaks preventing disengagement of the clutch which could result in unintentional vehicle movement, increased stopping distance, and engine stalling.2006-2007 Dodge Ram 3500>
The right outside rear view mirror glass has a curved (convex) mirror glass installed instead of a flat glass mirror required in all large vehicles.2007 300, Charger, Dakota, Durango, Liberty, Magnum, Nitro 4x2, Ram>
Automatic transmission software program causes momentary lock up of the drive wheels if the operator shifts from drive to neutral and back to drive at speeds over 40 mph.2007
Aspen, Durango> Improperly tempered right front steering knuckle could fracture causing a sudden loss of steering control.2007 Caliber, Charger, Commander, Compass, Grand Cherokee, Liberty, Magnum, Nitro, Sebring, Wrangler, 300>
Failure of the Antilock Brake System (ABS) control module software causes rear brakes lock up during certain braking conditions.2007 Sebring>
Automatic Temperature Control (ATC option) software causes failure of HVAC windshield defrosting and defogging.2007 Sebring>
Failure of the hood latch striker allows the hood to open while driving.Ferrari
2005-2006 Model F430 Coupe, Spider>
Failure of a part of the clutch pump causes inability to shift the manual 6-speed transmission. Dealers will replace the failed clutch right-angle union along with its seal ring and screw collars.Ford
1994-1996 Econoline; 1994-2002 F250—F550; 1996-2002 E450; 1998 Explorer, Mountaineer; 2000-2002 Excursion>
Speed control deactivation switch may overheat, smoke, or burn and start an underhood electrical fire. Dealers will install a fused wiring harness.2001-2002 Explorer Sport (with high back seats)>
Driver's side high back seat upper bolt that attaches the seat recliner mechanism to the seat back frame fractures allowing the seat to unexpectedly recline. Dealers will replace the bolt and seat tubular back frames and the lower bolt.2003-2004 Mustang Cobra> Accelerator pedal catches the cutout in the floor carpeting and fails to return causing unintended acceleration. Dealers will install a shield over the cutout in the carpet behind the accelerator pedal.
2005 Crown Victoria, Grand Marquis, Town Car>
Battery positive cable shorts against a #2 cross-member bolt causing an electrical fire.2005 Escape, Mariner> Dealers will install additional padding on roof rail and Driver’s A-pillar on those SUVs not equipped with side airbags or sunroofs.
2005 Five Hundred, Freestyle, Montego>
Straps that secure the fuel tank to the vehicle body may break, causing the fuel tank and fuel tank heat shield to drop on the driveshaft (all wheel drive vehicles) or exhaust system (front wheel drive vehicles).2005 Five Hundred, Montego, 2005-2006 Freestyle>
Water gets into the side door latch mechanism causing it to freeze in cold weather. The door latch pawl won’t latch the door when it’s closed. Dealers will install a shield over the front latches; seal a drain hole in the rear window trim molding on the freestyle rear side doors; and apply grease to all front and rear side-door latch mechanisms. (Alaska, Colorado, Connecticut, Delaware, Idaho, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, Montana, Nebraska, New Hampshire, New Jersey, New York, North Dakota, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, Wisconsin, And Wyoming).2005-2006 Freestar, Monterey> The power liftgate motor automatically disengages after it opens. If the liftgate strut fails, the liftgate can drop and injure a person beneath it. Dealers will reprogram the liftgate module.
2006 Escape, Expedition, E-150 thru 450 series vans, Explorer, F-150, Lincoln Mark LT, Mariner, Mountaineer, Ranger, Taurus>
Lack of grease on the windshield wiper motor output shaft gear may cause the gear teeth to distort or fracture during continuous use on the high speed setting resulting in the loss of wiper function.2006 Escape HEV>
Improperly tempered intermediate shaft fractures causing the powertrain to disconnect from the drive wheels and the transmission won’t hold the vehicle stationary.2006 F-150, Mark LT>
Software problem in the instrument cluster keeps the Antilock Brake System (ABS) warning light from coming on to warn of a failed ABS.2006 Lincoln Navigator>
Faulty automatic transmission parking pawl guide plate prevents the parking lock system from engaging after the transmission is placed in the park position.2007 Crown Victoria, Grand Marquis>
Improperly installed windshield leaks water, creates wind noise, squeaks, rattles, or fails to stay in place in a crash.General Motors
1999-2000 Sierra, Silverado>
Galvanized-braided-steel tailgate support cables used to support the tailgate in the horizontal position will fracture when loaded and if both cables break the tailgate would drop onto the rear bumper.2003-2006 Express, Savana>
Failure of the front and rear seat belt buckles to operate.2004 Avalanche; 2004-05 Suburban; 2004-06 Sierra, Silverado, Yukon Xl; 2005-2006 Avalanche 1500; 2006 Kodiak, 2006 Suburban 1500, Topkick 6500, 8.1L V8 (RPO L8-VIN G engine)>
Fracture of the retainer clip for the engine fuel-rail mounted pulse damper allows it to loosen from the fuel rail and leak fuel and catch fire.2004 Silverado; 2005
Montana, Tahoe, Sierra; 2005-2006 Envoy, Lacrosse, Rendezvous, Trailblazer; 2006 GMC G6, HHR, Hummer H3, Malibu> Original cloth seats were reupholstered with aftermarket leather seat cover kits. This prevents the automatic air bag passenger sensing system from functioning which disables the passenger’s airbag. GM will remove the cover and reimburse the cost, or buyback the vehicle.2004-2005 Cadillac XLR>
Daylight running light bulb or turn signal/parking lamp bulbs burn out prematurely from vibration caused by a loose fitting socket or from air leaking into the bulb. Dealers will replace the lamps and socket (if loose).2004-2006 Chevrolet
Colorado, GMC Canyon> Faulty brake lamp switch assembly causes loss of brake lamp function or brake lamps stay on. Center high-mounted stop lamp (CHMSL) and cruise control (if equipped) are also affected.2005-2006 Cadillac CTS, STS V6 Engines>
Failure of the low fuel level indicator and/or chime can allow the driver to run out of gas. Dealers will reprogram the ECM.2005 Cadillac SRX, STS>
Rear suspension weld failure allows the left or right toe link to separate. If this happens, the wheel will turn in or out which would affect vehicle control. Dealers will inspect/replace the toe link and if replaced will align the wheels.2005 Uplander, Montana SV6, Terraza, Saturn Relay; 2005-2006 Malibu, Malibu Maxx, Pontiac G6; 2006 Rendezvous>
Engine harmonic balancer isn’t tightened properly and may cause crankshaft key failure. This will damage the sprocket and timing gears, causing cylinder head, valve, pistons, and residual internal engine damage which will require engine repair or replacement.2005-2006 Corvette (with painted roof)>
Adhesive between the roof panel and the frame may separate, allowing the roof panel to detach from the vehicle and strike another vehicle.2006 Avalanche ,Canyon, Colorado, Envoy, Escalade, Escalade ESV, EXT, Express, Hummer H2, Hummer H3, Montana SV6, Rainier, Saturn relay, Savana, Sierra, Silverado, SSR, Suburban, Tahoe, Terraza, Trailblazer, EXT, Uplander, Yukon, Yukon Xl>
Failure to conform to DOT requirements with tire and loading information labels listing an inaccurate vehicle capacity weight.2006 Cadillac SRX, Sierra, Silverado; 2007 Avalanche 1500, Escalade EXT 1500, Canyon,
Colorado> Tire rim designation label on the driver's door edge missing the tire load rating.2006 Cadillac STS (all wheel drive 3.6L>
Torque monitoring functions of the electronic throttle control weren’t enabled in the PCM and could result in the throttle opening further than commanded by the driver which causes unintended acceleration. Dealers will reprogram the ECM.2006 Chevrolet Impala w/manual passenger seat adjuster>
The left floor mounting bracket may be mislocated allowing the seat adjuster to separate from the mounting bracket, increasing the risk of occupant injury.2006 Chevrolet Impala>
Manual passenger seat adjuster is mislocated and will break loose from the left floor mounting bracket in a severe vehicle crash, increasing the risk of occupant injury.2006 Hummer H1>
Steering-gear-to-frame attachment hardware comes loose and separates from the frame causing complete loss of vehicle steering.2006 Lucerne; Cadillac DTS V-8>
Power steering hose fails and leaks fluid causing loss of power steering assist, increased steering effort, and if it leaks on hot engine parts, an engine compartment fire could occur.2006 Uplander cargo vans>
No tire and loading information label was installed as required by DOT standards.2007 Chevrolet Aveo 1.6>
During crash testing the engine compartment fuel line fractured and four short circuits in the fuse box caused the fuel pump safety shutoff to fail. Dealers will replace the fuse block and install a redesigned section of fuel line.2007 Impala, Lacrosse, Grand Prix>
Improper bonding of the fuel barrier layer to the outer shell of the fuel tank allows gas vapors to seep out of the tank which can cause a fire.Honda
2001-2002 Acura MDX SUV>
Road salt corrodes the front suspension coil springs have insufficient corrosion protection and causes spring failure which could puncture a front tire. Dealers will install improved springs. (Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia).2006 Accord>
Bead area of the tires could have been damaged when mounted on the wheels.2006 Civic 2-door>
Failure of the front passenger Occupant Detection System to suppress air bag deployment when an infant or small child is in the front passenger seat.2006 Civic 2-door>
Rear windshield or rear quarter glass panels may become loose, rattle, lift from the window opening or separate from the window while driving increasing the safety hazard to traffic.Hyundai
2005-2007 Tucson>
Driver’s airbag doesn’t provide adequate protection for an unbelted small sized person (such as a small female). Dealers will replace the airbag.2006 Sonata>
Loose headlamp inner bezel causes the turn signal lenses to be improperly positioned.2006 Sonata>
The air bag warning label falls off the sun visor due to poor adhesive.Isuzu
2006 Ascender>
Failure to conform to DOT requirements with tire and loading information labels listing an inaccurate vehicle capacity weight.2006 I-280, I-350>
Faulty brake lamp switch assembly causes loss of brake lamp function or brake lamps stay on. Center high-mounted stop lamp (CHMSL) and cruise control (if equipped) are also affected.Jaguar
2006 XJ>
Moonroof reinforcement bar may contact the glass when slamming the door or hitting a bad bump and cause the moonroof glass to shatter.Kia
2003 Rio>
Rear outboard Child seatbelt automatic locking retractor (ALR) function may disengage and fail to hold the occupant in the event of a crash.2003-2005 Rio>
Failure to conform to DOT requirements for child restraint anchors which don’t latch onto the lower LATCH anchors located between the rear seat back and cushion.2006 Sedona w/adjustable brake pedals>
Stop lamp switch wiring harness is improperly positioned and contacts of the steering column U-joint assembly. Chaffed wires could short the wiring causing loss of brake lights, stalling, or no-start.2006 Sedona>
Rear caliper brake hoses contact rear suspension causing loss of fluid and braking.Jaguar
2005 S-Type>
fuel delivery module, jet pump module, and/or cluster valve inside the fuel tank is not properly sealed resulting in illumination of the malfunction indicator lamp, fuel odor, or gas leak which can cause a fire.Lotus
2005 Elise>
Gear shift lever on the 6-speed manual transmission breaks resulting in the inability to change gears.Mazda
2005 Tribute (Not equipped with side air curtains or moon roof)>
Failure to comply with DOT safety standards for occupant protection in interior impact because during testing, the test dummy’s head hit the A-pillar with excessive force. Dealers will add energy absorbing material located above the headliner.2005 Tribute> Dealers will install additional padding on roof rail and Driver’s A-pillar on those SUVs not equipped with side airbags or sunroofs.
2006 B-series trucks, Tribute>
Lack of grease on the windshield wiper motor output shaft gear may cause the gear teeth to distort or fracture during continuous use on the high speed setting resulting in the loss of wiper function.2006 Mazda5>
Water intrusion into the sliding door latch causing it to freeze in cold weather and when the door is opened the door latch pawl may remain in the open position resulting in the door not being able to be closed and latched. (Recall in Alaska, Colorado, Connecticut, Delaware, Idaho, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, Montana, Nebraska, New Hampshire, New Jersey, New York, North Dakota, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, Wisconsin, And Wyoming).2006 MX-5 Miata>
Bolt attaching the horn assembly to the steering wheel hub may fail during a driver side front air bag deployment in extremely low ambient temperature allowing the horn assembly to come loose and injure the driver. Dealers will replace the driver-side frontal air bag module.Mercedes Benz
1998-2004 SLK Model 170>
Failure of one or the side brake lights can occur if the bulb had been replaced with light bulbs 1073 which has higher wattage, generates more heat and will cause the bulb socket to deform and failure of the bulb to illuminate. Dealers will replace the rear lamp assemblies.2000-’01, ’02, 04, 2005 CL- & S-Class>
Failure of the dash illumination for the gauges and indicators. Dealers will replace the instrument cluster modules.2005-2006 C Class (equipped with sport model steering wheels)>
During low risk air bag testing an out-of-position unbelted small crash test dummy wasn’t properly restrained indicating a potential for injury. Dealers will install a new air bag inflator module.2005-2006 SLR McLaren>
Under hard operating conditions the engine heat can damage the alternator which can cause an engine compartment electrical fire. Dealers will improve the engine compartment cooling, install a modified control unit and new alternator.2006 R-Class>
Starter wiring harness protective sleeve chafes on the engine mount cover causing an electrical short and underhood electrical fire.2006 R-Class>
Threaded fastener securing the seat belt buckle to the second row seat(s) wasn’t threaded properly and fails to hold the occupant in a crash. Dealers will inspect and replace all seats as needed.2007 M- R-Class>
Accelerator pedal comes loose from its mounting stud causing difficulty of throttle operation.Mitsubishi
2005 Endeavor SUV> Front disc brake calipers are made of brittle metal which fractures causing unexpected loss of front brakes.
2006 Raider>
Four-wheel antilock brake system Electronic Control Unit (ECU) creates a front to rear brake imbalance causing the rear brakes to lock up prematurely during certain braking conditions which results in loss of driver control. Dealers will replace the ABS ECU.2006 Raider>
Static electric spark coming from the driver causes the turn signal, headlamps or windshield wipers to fail. Dealers will reprogram the body control computer.2007 Eclipse Spyder>
Front crossmember sheet metal was stamped too thin which allows separation of the passenger side lower control arm from the crossmember and loss of steering control.2007 Eclipse, Eclipse Spyder>
Faulty key lock cable causes the ignition interlock to become inoperative and the ignition key can be removed without shifting the automatic transmission into park which can allow the vehicle roll if the parking brake isn’t engaged.Nissan
2003 Altima 2.5>
Flaw with the engine coolant temperature sensor location causes erroneous signals to the engine control computer (ECM) which responds to the faulty signals by causing engine stalling at slow speeds. Dealers will reprogram the ECM.2003-2004 350Z, Infiniti G35; 2003-2006 Infiniti FX35, FX45>
Fuel filler hose cracks from exposure to ozone causing a fuel leak during refueling. Note: The onboard diagnostic system may detect the leak and turn on the dash warning light.2003-2006 Infiniti FX35 and FX45>
Headlamp assemblies do not meet DOT headlamp photometric requirements and providing inadequate illumination of the roadway.2003-2006 Murano>
In a high speed frontal crash, the rear outboard seatbelt gets cut by a sharp edge of the rear seat back hinge causing the belt to fail to restrain the occupant.2004-05 Quest>
Seat striker mounting bracket securing the folding 3rd row seat to the floor breaks loose.2004-06 Maxima>
Driver’s seat lumbar support wiring shorts under the seat causing an electrical fire.2004-2006 Infiniti Q45>
Tail lamp assemblies do not meet DOT photometric requirements and produce inadequate illumination and conspicuity. Dealers will replace the tail lamp assemblies.2004-2006 Titan crew cab>
Flexing of the wiring harness going to the rear doors causes the wires to break which can deactivate or deploy the driver’s seat belt tensioner, or deactivate the occupant classification system and the passenger’s airbag. Dealers will reroute the wiring harness and install a protective cover which prevents over flexing.2005 Murano>
Gas tank EVAP system fitting breaks off from the fuel tank causing the dash indicator light to come on and gas leakage which could cause a fire.2005-2006 Frontier King Cab> In a severe side impact crash the fuel filler cap tether may be stretched to the point of unscrewing the cap resulting in fuel spillage.
2005-2006 Murano; 2007 Maxima >
The ignition and steering wheel can be locked without the transmission in the park position, which will allow the vehicle to roll away.2006 Altima, Maxima>
cracks in a bracket which holds part of the rear suspension subframe compromise stability causing loss of vehicle control under severe driving conditions.2006 Altima, Sentra 2.5L 4-cylinder>
Piston ring failure causes excessive engine oil consumption. If the oil level isn’t maintained, engine damage can occur and in extreme cases result in an engine fire. Nissan has not yet provided a remedy for this campaign.2006 Titan King Cab trucks> Improper weld in the right side rear door upper latch assembly allows the door to open increasing the risk of injury to occupants.
2006-2007 Infiniti G35 Coupe>
Headlamp assemblies do not meet DOT photometric requirements and produce inadequate illumination of the roadway. Dealers will replace the headlamp assemblies.2007 Versa>
Missing warning on the brake fluid reservoir cap.Porsche
2004-05 911 Carrera S, 4S>
Faulty welds allow the exhaust pipe tips to come off and fall on the road creating a hazard to other vehicles.Rover
2006 Range Rover Sport with 9J-19” wheels>
The left front brake hose, the wheel speed sensor, or brake pad wear warning sensor wiring is damaged by the wheel balance weight causing the brake pad wear warning light to come on, ABS failure, extended brake pedal travel, and partial loss of brakes. Dealers will replace 'clip-on' wheel balance weights with 'stick-on' weights.2005-2006 Land Rover LR3; 2006 Range Rover Sport>
It’s possible to remove the ignition key when the transmission shift lever is not in park. Dealers will install revised software in the PCM.Saab
2001 9-3>
The retaining tabs holding the fuel lines to the fuel pump were damaged during production which could allow the lines to come loose and leak fuel. Dealers will secure the fuel lines to the fuel pump.2000-2002 9-3, 9-5 B205/B235 with 4-cylinder gas engines; 2001 9-5 with B308 6-cylinder gas engines>
High electrical loads cause overheating and burnout of the Isolated Gated Bipolar Transistor (IGBT) within the Ignition Discharge Module (IDM). This most often occurs at engine start-up, but it may also occur while the engine is running, resulting in stalling.2002-2003 Model 9-5 B308 6-cylinder>
Increased susceptibility to electrical loads, most often during startup, causes overheating and burnout of a transistor located inside the ignition module resulting in engine stalling. Dealers will replace ignition modules older than 12-2003.Suzuki
2006 Grand Vitara>
Left side of the retainer rear drive shaft may crack and the gears may get stuck due to oil leakage by the retainer which can lead to the rear differential gears locking up and the locking up the wheels.Toyota
Failure to comply with DOT requirements for "seat belt assembly anchorages" because the anchor bolt for the rear, left-hand side seat belt buckle directly behind the driver's seat is too weak and the rear seat occupant may not be properly restrained in the event of a crash.
2004-05 Prius gas-electric hybrid>
Computer software program glitch causes the gasoline engine to suddenly stall.2004-2005 Lexus RX330; 2006
Lexus RX400H; 2004-2005 Highlander; 2006 Highlander HEV sport utility and hybrid vehicles> Two retaining clips for the driver's side forward center console come loose and separate from the floor carpet cover allowing the cover may to interfere with the accelerator pedal rod resulting in unintended acceleration.2004-2006 Lexus LS, Prius, RAV4; 2005-2006 Avalon, Tacoma; 2005-2006 Scion tC; 2006 Lexus GS, IS; 2007 Camry>
Air bag inflator for the side, curtain shield, and knee air bags have too little propellant to properly inflate the air bag.2004-2006 Prius>
Electric power steering system intermediate shaft and sliding yoke connection may separate or the sleeve may fracture when making rapid steering corrections causing loss of steering control.2005-2006 Scion tC>
Inadvertent deployment of the side impact seat-bolster and curtain side air bags. This can occur if the door is slammed close while the vehicle’s ignition is in the “on” position or within 90 seconds of turning the ignition key off. Until the vehicle is repaired, use minimal force/speed to close the doors or wait 90 seconds after turning off the ignition before closing the doors. Dealers will replace the two side impact air bag sensors and install urethane pads in the doors.2006 Lexus GS, IS>
Failure of the driver and front passenger seat belt emergency locking system causes the retractors to become locked and not release which prevents the use of the seatbelt.2006 Camry>
Tire and loading information label or placard on the driver's side B-pillar incorrectly indicates the spare tire size.2006 Lexus IS250>
inadequate clearance between the accelerator pedal linkage and a plastic pad embedded into the vehicle's carpet causing accelerator pedal to become stuck resulting in unintended acceleration. Dealers will inspect the clearance of the gas pedal and carpet, replace the pedal assembly with a revised assembly, and modify the carpet.2006
Tacoma trucks> During assembly the tire bead may be damaged and a bulge may form on the sidewall and leak air.2007 Camry>
incorrectly routed tether strap for Curtain Side Air Bags (CSA option), prevents the CSA from deploying properly in a side impact or rollover crash.2007 FJ Cruiser equipped with Bridgestone Dueler or Dunlop Grandtrek tires>
Damage to the tire inner bead causes a bulge to develop on the sidewall and tire leak or blowout.Volkswagen
1996-1997 Audi A4>
Anchor point of the ignition switch spring may crack keeping the switch from returning to the run position which will prevent operation of accessories such as windshield wipers and headlights.1998-2000 Audi A6, A6 Avant, S6, S6 Avant>
When performing repair for recall 04V133000, if the plastic cover wasn’t securely installed LH side support cross member,1999-2002 Jetta; 1998-2002 New Beetle>
Malfunctioning brake light switch installed incorrectly during safety recalls 03V-265 or 04V-096. causes the brake lights to be inoperative, or remain on.2004-2005 Audi A8>
Driver's frontal air bag may not unfold properly in the event of a crash and therefore may not inflate as designed.2006 Audi A3>
Failure of the either the left or right side curtain air bag inflation module. In the event of a crash, the air bag may not inflate as designed.2006 New Beetle 2.5L>
The tire label lists an incorrect tire size for cars fitted with 17-inch wheels.2006 Passat>
Heavy rain gets into the wiper motor causing it to fail. Dealers will install a special cover and sealing kit.2006 Passat>
The left and right tie rod securing nut may loosen, resulting in separation of a tie rod and loss of steering control.2006 Phaeton> Vehicles with four seats tire information label incorrectly states the vehicle as a five passenger vehicle rather than a four passenger vehicle.
2006-2007 Audi A8>
Low battery voltage causes the airbag control unit to deactivate the passenger side frontal airbag and turn on the “Passenger Airbag Off” and airbag dash warning lights.2006-2007 Passat, 2007 Passat Wagon>
Vacuum line in the 2.0L engine fractures at low ambient temperatures and become disconnected causing loss of power brake assist.Volvo
1999-2000 S70, V70XC; 1999-2001 S80; 1999-2002 C70, C70 convertible, V70; 2001 XC70;
2001-2002 S60>
Powertrain control module software glitch turns on the check engine light and inadvertently go into limp home mode because of irregularities in the throttle position sensor or dirty throttle housing.2003-06 XC90 SUV>
The wiper arm strips from the linkage shaft if the blades are stuck with ice/snow.2003-2006 XC90> At high loads the outer tie rod ball joint deforms allowing the nut to loosen with a loss of clamping force which can cause fatigue fracture of the outer tie rod ball joint. The driver may notice the vehicle is difficult to steer. Loss of steering control increases the risk of a crash. Dealers will replace the outer ball joint tie rods with improved parts.
2004-2006 S40 and V50 (with T5 turbo)>
The polyamide fuel line melts from extreme temperatures from the turbo/exhaust manifold causing a fuel leak. Dealers will install a Teflon fuel line.2005-2006 S60, S80, V70>
The tire loading and pressure information label is incorrect.XC90>
Fatigue fractures of the tie rod ball joints cause loss of steering control. Note: The recall is being carried out under the ZF Lemforder Corp name.Motorcycles
2006 BMW R1200 GS Adventure>
Tire Pressure monitoring System (cross-spoke wheel TPS option) leaks (blowout) at the TPS mounting hole causes sudden tire deflation.2006 Ducati ST3 & ABS>
Wiring harness for the fuel pump module burns on the exhaust manifold causing loss of fuel pump and sudden engine stalling.Big Dog 2004 Boxer, Chopper DT; 2004-2005 Bulldog; 2004-2006 Chopper, Mastiff, Pitbull, Ridgeback; 2005 Chopper DT; 2006 K-9>
Kickstand spring may stretch and detach from the mounting bracket or the kickstand which allows the kickstand to deploy into the extended position.Big Dog 2005 Bulldog; 2005-2006 Chopper, Mastiff>
The long pivot bolt may bend or break and cause the rear fender to abrade against the rear tire. Dealers will replace the long pivot bolt and, if necessary, straighten the rear frame side panel. The short left side pivot bolt and pivot shaft may also be replaced.Big Dog: 2005 Bulldog; 2005-2006 Chopper, Mastiff>
The ignition module mounted in the battery tray makes the module susceptible to vibration which causes stalling without any prior warning. Dealers will install a new ignition module mounting system.Big Dog: 2005 Bulldog>
Front fender brackets allow the front fender to detach and catch in the spokes. If repaired under the previous recall campaign, it will need another repair.Big Dog: 2005-2006 Mastiff, Chopper; 2005 Chopper DT, Bulldog, Pitbull, Ridgeback; 2006 K-9>
Electronic harness control module failure causes total shut down of the vehicle's electronic power.BMW 2004-2005 R1200 GS; 2005 K1200 S; R1200 ST; R1200 GS; 2006 R1200 RT>
Loss of ABS capability could occur under rapid, repeated, and unusually harsh braking. Dealers will add a banjo bolt with a flow restrictor to the brake line, and on certain models dealers will install new front brake discs of a slightly larger thickness.BMW 2006 R1200 HP2; 2007 R1200 S>
Incorrectly installed final-drive assembly o-ring can leak oil onto the rear brake disc. Dealers will install a new o-ring in the final-drive assembly.BMW: 2004-2006 R1200 GS, MY 2005-2006 R1200 RT, ST>
Removal of the front left brake caliper causes the ABS sensor cable to be routed incorrectly and contact the front brake disk causing loss of ABS function.BMW: 2006 R1200 GS; R1200 GS HP2; R1200 RT> Clutch components come loose while underway and can suddenly break loose and fly through the engine casting.
Buell: 2006 Ulysses>
Tall windscreens P/N 58214-06YA retention fasteners fail and allow the windscreen to come off at highway speeds hitting the driver.Buell: 2006 XB12X>
Pivot bolt for the sidestand leg or the mounting bracket bolts could break and compromise the sidestand's performanceGenuine Scooters: 2005 Stella>
The headlight lens could loosen or detach.Harley Davidson: 2006 FXD, FXDC, FXDL, FXDWG, FXD35, FXDB>
When the transmission neutral indicator light is illuminated the motorcycle could drop into gear unexpectedly. Dealers will replace the shifter cam (drum), the detent arm, and the neutral switch with upgraded parts.Harley-Davidson 2004-2005 883R, 1200>
Faulty brake master cylinder cup prevents the secondary piston from returning completely which makes the brake light stay illuminated.Harley-Davidson: 2006 Dyna>
Battery caddy bolt loosens and allows the battery positive terminal to rub through its protective boot and short against the cover causing sparks and electrical fire.Honda 2006 VT750C>
Failure of the wire harness plug for the handlebar-mounted headlight switch causes sudden loss of headlights. Dealers will replace both left and right handle switch assemblies.Kawasaki 2006 ZX1400A6F>
Bolts holding the “vehicle down” sensor may come loose and allow the sensor to fall out of its mounting bracket causing the engine to suddenly stop.Kawasaki: 2006 ZX1000D6F, ZX1000D6F/L>
Steering damper bolt comes out causing loss of steering control.KTM: 2001-2003 LC4 640 Adventure>
Premature wear on the front wheel components can occur. Dealers will replace the complete front wheel.Polaris: 2000 Victory V92>
Retaining nut for the Gates drive belt front sprocket fails to hold the sprocket in place allowing it to loosen and the transmission to lockup.Polaris: 2001 Victory V92; 1999-2000 V92>
Transmission replacement kits have a third gear which can fail in an overload condition when shifting at high RPM. Dealers will install a rear sprocket damper assembly.Polaris: 2006 Victory Jackpot, ANSS, CNSS >
The VIN decal located on the left front down tube of the frame incorrectly lists the gross axle weight rating (GAWR) for the front axle as 405 pounds when it should be 390 pounds.Suzuki 1998-2006 VL1500; 2005-2006 VL1500T>
Repeated stress around the right front fuel tank mounting point causes metal fatigue and a crack to form resulting in a fuel leak.Suzuki 2003 SV1000; 2003-2006 SV650, SV650S, SV1000S>
California-specification gas tank subjected to stress from vibration will crack in the area where the liquid/vapor separator bracket is welded inside the fuel tank causing a gas leak.Suzuki 2005-2006 VL800, VZ800>
improperly routed ignition switch wiring harness rubs against the clutch cable/throttle cable causing a short circuit resulting in engine stall or loss of the lights. Dealers will re-route the wiring harness, replace the lock set, ignition switch, and clutch/throttle cable.Suzuki: 2005 AN650 Burgman scooters>
Improperly seated threads of the fuel pump retaining ring prevents it from sealing properly on the plastic fuel tank resulting in fuel leakage.Triumph: 2006 Rocket> Improperly torqued handlebar clamp bolts.
Triumph: 2006 Sprint 1050, Sprint 1050 ABS, Speed Triple 1050 and Daytona 955I>
Anti-rotation stop bolt on the rear brake caliper may shear allowing the caliper to hit the swing arm causing loss of control.Triumph: 2006-2007 SPRINT ST>
Rear drag link-through bolt may bend or fracture allowing the rear tire to contact the underside of the rear mudguard and cause loss of control. Dealers will install a high grade nut and replace the original design 3 separate sleeves with a single-through sleeve.Victory: 2004-2005 Kingpin; 2004 Vegas>
Failure of the welded joint on the shift lever shaft prevents the driver from shifting gears.Victory: 2006 Kingpin, Kingpin Deluxe, Vegas, Vegas Eight Ball>
Rear axle may crack or break at the retaining plate groove on the right side causing loss of control, increasing the risk of a crash.Yamaha 1999-2001>
Midnight Star, MM Limited, Road Star, Star Silverado> Failure of a transmission circlip causes unexpected transmission lockup. Note: This is an expansion of a previous 2003 recall 03V309.Yamaha: 2002-2005 XV1700; 2003-2005 FJR1300; 2004-2005 FZS600, YZF-R1>
Faulty throttle position sensor causes intermittent unstable idle and engine stall If the driver disengages the clutch in a low gear while riding with a stalled engine it could cause the rear tire to lose traction.Yamaha: 2006 YZFR6>
Air filter mounting screws fall out and jam open the throttle which prevents the driver from reducing speed.Tires
Cooper Dick Cepek Radial F-C II, mesa C/T, Tempra Trailcutter Radial RT, COOPER Discoverer S/T, Durango Radial XTR, Mastercraft Courser C/T, Dean Mud Terrain Radial SXT, size LT285/75R16, and Pro Comp Xtreme A/T, size 38.50X14.50R20LT, made between 02.01.04, and 01.21.06>
Low tread gauge in the shoulder slot area of the tire causes inadequate rubber coverage of the belt edge. This causes cracking at the base of the shoulder slots exposing the belt wire and accelerated belt degradation which causes tread separation or breaking of the ply cords and a blowout.Cooper Trendsetter SE, Mastercraft A/S IV, Dean Alpha 365 A/S, and Starfire Flite-Line IV made between 11.21.04, and 07.30.05>
Material in the upper sidewall may come loose causing voids which result in loss of air pressure and early failure.Cooper Zeon 2XS, sizes 235/35R19XL and 245/40R20, and Mastercraft Avenger ZHP, size 235/35R19XL, made between April 25, 2004, and
February 12, 2005>Compression cracking of the inner liner causes the tire to loose air pressure and early failure.Big O Aspen, H/R Euro Tour, SXP G/T; TBC Classic Radial, Cordovan Centron, Grand Prix Performance GT, Multi-Mile Matrix, Wild Country Radial Rvt, Sigma Regent, Shadow, Stampede, Supreme, Sigma Tempest, Vanderbilt Turbo Tech>
Tire steel belt wire coating allows the steel belt to corrode causing belt separation and tire failure.Cooper: Cobra, Discoverer, Lifeliner, Trendsetter; Dean: Alpha, Quasar, Stinger, Trailcat, Wildcat; Dominator, Sport, Sport SR4; Generic: Mentor, Mastercraft; Courser A/S IV, Avenger, Courser, Sensys 01; Starfire: Flite-line, Solarus, Spectrum, SX 5000 tires made 08.06.06 - 08.19.06 (DOT 3206- 3306)>
Tire steel belt wire coating allows the steel belt to corrode causing belt separation and tire failure.Pep Boys Cornell; Definity Dakota, EX600; Futura 2000, GLS; Super Sport; Scrambler tires made 08.06.06 - 08.19.06 (DOT 3206- 3306)>
Tire steel belt wire coating allows the steel belt to corrode causing belt separation and tire failure.Firestone Destination A/T P265/75R16 made from 01.29.06 & 02.04.06>
Tire inner liner damage allows air loss.Big "O" & Mesa C/T LT285/75R16 tires, made between 11/7/04 – 1/14/06>
low tread gauge in the shoulder slot area of the tire causes inadequate rubber coverage and eventually results in cracking at the base of the shoulder slots, exposed belt wire, accelerated belt degradation and separation, broken ply cords and loss of air.El Dorado
, Jet/Tel, Jetzon, Laramie, Sumitomo tires made 08.06.06 - 08.19.06 (DOT 3206- 3306)> Tire steel belt wire coating allows the steel belt to corrode causing belt separation and tire failure.Michelin tires>
Pilot Sport 255/35ZR20 97Y may develop a blister in the sidewall which can blowout suddenly.Mickey Thompson Dick Cepek, Baja
tires made 08.06.06 - 08.19.06 (DOT 3206- 3306)> Tire steel belt wire coating allows the steel belt to corrode causing belt separation and tire failure.
Other
Airtex aftermarket fuel pumps>
Pump module internal failure causes loss of power and stalling. (P/N’s. E7089M, E7094M, E7113M, E7129M, for use in 1995-1996 Stratus; 1995-1997 Breeze, Cirrus; 1996-1999 Sebring; 1998-2000 Caravan, Grand Caravan, Grand Voyager, Voyager).Federal-Mogul fuel pumps>
Mechanical pumps P/N M847 sold by NAPA and Carter contain a defective valve housing that leaks fuel.R&B aftermarket CMFI return fuel lines for 1992-1995 Astro, Blazer, Bravada; GMC S-Series, Jimmy, Safari, Sonoma; 1992-1993 GMC Typhoon>
(Not OEM) sold as HELP 55163; NAPA 700-3270; The Connection 2560001. The return fuel line mechanical bleed valve leaks fuel causing an underhood engine fire.Click here if you have received a recall notice within 2006 and do not see it listed above
If you like this informative info and want more...
join MotorWatch and read them in the
MotorWatch Newsletter.
What are you waiting for? Hurry up!
Your life could be saved by our valuable info!